Frequent question: How do I speed up my ezgo gas golf cart?

How do I make my EZ Go gas golf cart go faster?

One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.

Can you make a gas golf cart go faster?

Increase the RPM

An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.

How can I make my EZ Go Express faster s4?

Loosen the small nut and tighten the larger nut.

The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.

THIS IS EXCITING:  What is a golf rough?

Why is my gas golf cart slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.

How do I get more torque out of my gas golf cart?

Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.

How fast can a gas golf cart go?

A gas cart can run up to 18 – 20 mph and there are not many speed upgrades you can do to one. In addition, electric carts will get up to top speed faster as well.

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.

How do I fix my EZ Go speed controller?

Here are 5 steps you should follow for a DIY fix to your golf cart’s speed controller.

  1. Flip the maintenance switch. …
  2. Reset the battery cable. …
  3. Check your connections. …
  4. Test the solenoid. …
  5. Check your controller’s power output.

Where is the speed sensor on a ezgo golf cart?

Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.

THIS IS EXCITING:  What is golf casual attire?

How do I test my ezgo speed controller?

Connect the negative probe to the controller’s M terminal and positive probe to the B+ terminal. Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor.