Why wont my gas golf cart go forward or reverse?

What would cause a golf cart not to move?

Solenoid Wear

When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.

Why does my golf cart click but not move?

A damaged battery or damage to the internal controller could cause your club vehicle to make a clicking sound but not move. Due to dust building inside the battery ports, a Club Car golf cart can start clicking but not move. These are the causes of clicking sound on the golf cart but won’t move, among others.

What do you do if your golf cart won’t go?

First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don’t hear clicking, it’s time to take a look at your cart’s batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.

THIS IS EXCITING:  Can lightning strike a golf ball in the air?

How do you troubleshoot a gas golf cart?

Instructions

  1. Check the gas tank to make sure there is enough fuel for operation. …
  2. Remove the oil dipstick and check that the oil level is at or just above the add or fill maker. …
  3. Inspect the battery of the golf cart. …
  4. Examine the wiring and switches. …
  5. Remove the air filter from the engine to access the carburetor.

What makes golf carts go forward?

The next most common problem you’re likely to experience with your golf cart is a malfunctioning controller. Controllers for direction come in two varieties – forward and reverse. As a result, a cart that will go forward but not reverse may have a broken controller for the reverse that needs to be fixed or repaired.

How do I know if my golf cart controller is bad?

Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.

What does a solenoid do on a golf cart?

The solenoid is the small unit that rides on top of the starter in the engine. The solenoid brings power from the battery to the rest of your golf cart. With the use of an electric charge, a solenoid may generate a magnetic field.

Where is the reset button on a ezgo golf cart?

Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.

THIS IS EXCITING:  Best answer: What is considered the most beautiful golf course in the world?

What causes a gas golf cart to lose power?

Over time, your wires may work themselves loose from their connectors or end up with damaged connectors, frayed with common corrosion issues. However, there is also a chance that your wires may end up broken or frayed, leading to sparks and poor electrical conduction.

Where is the reset button on a golf cart motor?

The reset button acts as a mini circuit breaker for the motor, so it will correct any minor errors. Expose the motor (you’ll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected.

How do you test a fuel pump on a golf cart?

A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you’ve enjoyed out tutorial on golf cart fuel pumps.

How do you test a ignition switch on a golf cart?

Testing a Club Car Ignition Switch

  1. Find the back and red wires on the back of your battery pack.
  2. Connect the black wire to the negative terminal and the red to the positive.
  3. Keep the cart turned off while you work on it.
  4. Check the wires with a probe meter while the cart is off – only one wire should have a charge.

What starts a gas golf cart?

They usually have a lever or a button that allows you to switch from forward to reverse and back again. When you step on the pedal, the cart takes a second to initiate and then powers forward with a sometimes startling jolt.

THIS IS EXCITING:  How many golf clubs do I need to start?